Skip to main content

Continuous control of tracheal cuff pressure: an effective measure to prevent ventilator-associated pneumonia?

Abstract

In a previous issue of Critical Care, Lorente and colleagues reported the results of a prospective observational study aiming at evaluating the effect of continuous control of cuff pressure (Pcuff ) on the incidence of ventilator-associated pneumonia (VAP). The results suggest a beneficial impact of this intervention on VAP prevention, which is in line with the results of a recent randomized controlled study. However, another randomized controlled study found no significant impact of continuous control of Pcuff on VAP incidence. Several differences regarding the device used to control Pcuff, study population, and design might explain the different reported results. Future randomized multicenter studies are needed to confirm the beneficial effect of continuous control of Pcuff on VAP incidence. Furthermore, the efficiency and cost-effectiveness of different available devices should be compared. Meanwhile, given the single-center design and the limitations of the available studies, no strong recommendation can be made regarding continuous control of Pcuff as a preventive measure of VAP.

Introduction

In a previous issue of Critical Care, Lorente and colleagues [1] reported the results of a prospective study aiming at evaluating the impact of continuous control of cuff pressure (Pcuff) on the incidence of ventilator-associated pneumonia (VAP). They included a large number of patients intubated and ventilated for more than 48 hours (150 patients in a continuous control group and 134 patients in a routine care group). The target Pcuff was 25 cm H2O in both groups. Whereas the main clinical characteristics were similar in the study groups, VAP rate was significantly reduced by the use of continuous control of Pcuff. Additionally, continuous control of Pcuff and use of subglottic secretion drainage were independently associated with reduced incidence of VAP. Kaplan-Meier analysis showed a significantly higher proportion of patients remaining free from VAP using continuous control of Pcuff compared with intermittent control using a manometer.

Table 1 Characteristics of studies assessing the impact of continuous control of cuff pressure on ventilator-associated pneumonia incidence

Comparison with previous studies

The strengths of this study are the large number of included patients and adjustment for confounders using Cox proportional analysis. As acknowledged by the authors, the absence of randomization and blinding is one of the limitations of the study. In addition, the impact of continuous control of Pcuff on tracheal ischemic lesions was not evaluated. However, previous animal and clinical studies found no significant effect of this intervention on the incidence of intubation-related tracheal damage [2],[3]. Furthermore, efficiency of the electronic device used by the authors in continuously controlling Pcuff was not previously evaluated in critically ill patients.

The lower rate of VAP in patients who received continuous control of Pcuff is in line with the results of a recent randomized controlled study performed by our group [4], although the primary outcome of that study was not VAP but abundant microaspiration of gastric content. Another randomized controlled study found no significant impact of continuously controlling Pcuff on VAP incidence [5]. Several differences regarding the device used to control Pcuff, study population, and design might explain the different reported results (Table 1).

Microaspiration and underinflation of tracheal cuff

Microaspiration of contaminated oropharyngeal and gastric secretions is the main mechanism of entry of bacteria into the lower respiratory tract [6]. Recently, several markers of microaspiration, including pepsin and salivary amylase, were described and validated [7]-[9]. Interestingly, these markers are quantitative, allowing accurate evaluation of microaspiration. It is well known that subsequent development of VAP is tightly correlated to the quantity of bacteria present in the lower respiratory tract [10]. The use of these biomarkers in critically ill patients could be helpful in evaluating the efficiency of a new device aiming at reducing the incidence of VAP via the reduction of microaspiration, before conducting large multicenter studies to test the effect of such a device on VAP incidence.

Underinflation of the tracheal cuff is usually defined as Pcuff of less than 20 cm H2O and was identified by one prospective observational study as an independent risk factor for VAP in a subgroup of patients without antimicrobials [11]. However, microaspiration could occur at higher Pcuff depending on tracheal anatomy and patient movements [12]. In fact, microaspiration is a multifactorial process related to mechanical ventilation, tracheal tube, enteral nutrition, and general factors. Therefore, to prevent microaspiration and subsequent VAP, all of these factors, not just Pcuff, should be taken into account.

Current practice and future studies

In spite of routine manual control of Pcuff using a manometer, intubated critically ill patients spend a large amount of time with underinflation and overinflation (>30 cm H2O) of the tracheal cuff. In a cohort of 101 critically ill patients intubated with a polyvinylchloride-cuffed tube, Pcuff was continuously recorded for 8 hours after manual adjustment of Pcuff at 25 cm H2O [13]. Only 18 % of study patients spent 100 % of recording time with a normal (20 to 30 cm H2O) Pcuff. Fifty-four percent of study patients developed cuff underinflation, 73 % developed cuff overinflation, and 44 % developed both. Subsequent studies reported similar results in patients intubated with polyurethane-cuffed tracheal tubes [14],[15]. Several devices aiming at continuously controlling Pcuff, including the one used by Lorente and colleagues, are currently available on the market. Unfortunately, the efficiency of some of these devices was never tested in clinical studies. Therefore, before these devices can be used in critically ill patients, well designed and performed studies are required.

Conclusions

Future randomized multicenter studies should confirm the beneficial effect of continuous control of Pcuff on VAP incidence. Furthermore, the efficiency and cost-effectiveness of different available devices should be compared. Meanwhile, given the single-center design and the limitations of the available studies, no strong recommendation can be made regarding continuous control of Pcuff as a preventive measure of VAP.

Abbreviations

Pcuff:

Cuff pressure

VAP:

Ventilator-associated pneumonia

References

  1. Lorente L, Lecuona M, Jiménez A, Lorenzo L, Roca I, Cabrera J, Llanos C, Mora ML: Continuous endotracheal tube cuff pressure control system protects against ventilator-associated pneumonia. Crit Care. 2014, 18: R77-10.1186/cc13837.

    Article  Google Scholar 

  2. Nseir S, Duguet A, Copin M-C, De Jonckheere J, Zhang M, Similowski T, Marquette C-H: Continuous control of endotracheal cuff pressure and tracheal wall damage: a randomized controlled animal study. Crit Care. 2007, 11: R109-10.1186/cc6142.

    Article  Google Scholar 

  3. Touat L, Fournier C, Ramon P, Salleron J, Durocher A, Nseir S: Intubation-related tracheal ischemic lesions: incidence, risk factors, and outcome. Intensive Care Med. 2013, 39: 575-582. 10.1007/s00134-012-2750-6.

    Article  CAS  Google Scholar 

  4. Nseir S, Zerimech F, Fournier C, Lubret R, Ramon P, Durocher A, Balduyck M: Continuous control of tracheal cuff pressure and microaspiration of gastric contents in critically ill patients. Am J Respir Crit Care Med. 2011, 184: 1041-1047. 10.1164/rccm.201104-0630OC.

    Article  Google Scholar 

  5. Valencia M, Ferrer M, Farre R, Navajas D, Badia JR, Nicolas JM, Torres A: Automatic control of tracheal tube cuff pressure in ventilated patients in semirecumbent position: a randomized trial. Crit Care Med. 2007, 35: 1543-1549. 10.1097/01.CCM.0000266686.95843.7D.

    Article  Google Scholar 

  6. Nseir S, Zerimech F, Jaillette E, Artru F, Balduyck M: Microaspiration in intubated critically ill patients: diagnosis and prevention. Infect Disord Drug Targets. 2011, 11: 413-423. 10.2174/187152611796504827.

    Article  CAS  Google Scholar 

  7. Metheny NA, Clouse RE, Chang Y-H, Stewart BJ, Oliver DA, Kollef MH: Tracheobronchial aspiration of gastric contents in critically ill tube-fed patients: frequency, outcomes, and risk factors. Crit Care Med. 2006, 34: 1007-1015. 10.1097/01.CCM.0000206106.65220.59.

    Article  Google Scholar 

  8. Dewavrin F, Zerimech F, Boyer A, Maboudou P, Balduyck M, Duhamel A, Nseir S: Accuracy of alpha amylase in diagnosing microaspiration in intubated critically-ill patients. PLoS One. 2014, 9: e90851-10.1371/journal.pone.0090851.

    Article  Google Scholar 

  9. Filloux B, Bedel A, Nseir S, Mathiaux J, Amadéo B, Clouzeau B, Pillot J, Saghi T, Vargas F, Hilbert G, Gruson D, Boyer A: Tracheal amylase dosage as a marker for microaspiration: a pilot study. Minerva Anestesiol. 2013, 79: 1003-1010.

    CAS  Google Scholar 

  10. Nseir S, Marquette C-H: Diagnosis of hospital-acquired pneumonia: postmortem studies. Infect Dis Clin North Am. 2003, 17: 707-716. 10.1016/S0891-5520(03)00075-8.

    Article  Google Scholar 

  11. Rello J, Soñora R, Jubert P, Artigas A, Rué M, Vallés J: Pneumonia in intubated patients: role of respiratory airway care. Am J Respir Crit Care Med. 1996, 154: 111-115. 10.1164/ajrccm.154.1.8680665.

    Article  CAS  Google Scholar 

  12. Lizy C, Swinnen W, Labeau S, Poelaert J, Vogelaers D, Vandewoude K, Dulhunty J, Blot S: Cuff pressure of endotracheal tubes after changes in body position in critically ill patients treated with mechanical ventilation. Am J Crit Care. 2014, 23: e1-e8. 10.4037/ajcc2014489.

    Article  Google Scholar 

  13. Nseir S, Brisson H, Marquette C-H, Chaud P, Di Pompeo C, Diarra M, Durocher A: Variations in endotracheal cuff pressure in intubated critically ill patients: prevalence and risk factors. Eur J Anaesthesiol. 2009, 26: 229-234. 10.1097/EJA.0b013e3283222b6e.

    Article  Google Scholar 

  14. Nseir S, Zerimech F, De Jonckheere J, Alves I, Balduyck M, Durocher A: Impact of polyurethane on variations in tracheal cuff pressure in critically ill patients: a prospective observational study. Intensive Care Med. 2010, 36: 1156-1163. 10.1007/s00134-010-1892-7.

    Article  Google Scholar 

  15. Jaillette E, Zerimech F, De Jonckheere J, Makris D, Balduyck M, Durocher A, Duhamel A, Nseir S: Efficiency of a pneumatic device in controlling cuff pressure of polyurethane-cuffed tracheal tubes: a randomized controlled study. BMC Anesthesiol. 2013, 13: 50-10.1186/1471-2253-13-50.

    Article  Google Scholar 

Download references

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Saad Nseir.

Additional information

Competing interests

SN has received lecture fees from and served on the advisory board of Covidien (Dublin, Ireland). AR and EJ declare that they have no competing interests.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Rouzé, A., Jaillette, E. & Nseir, S. Continuous control of tracheal cuff pressure: an effective measure to prevent ventilator-associated pneumonia?. Crit Care 18, 512 (2014). https://0-doi-org.brum.beds.ac.uk/10.1186/s13054-014-0512-2

Download citation

  • Published:

  • DOI: https://0-doi-org.brum.beds.ac.uk/10.1186/s13054-014-0512-2

Keywords